CUMMINS ED-3 Manual de instalación

Installation Manual English Version 03/2014 Doc 17855 Generator Set Cummins NPower GF Series

Natural Gas Generator Set Installation Manual-GF SeriesDoc. 17855, Rel. 03/20141-2WARNINGExhaust Gases Are Deadly.The engine exhaust from this product

Natural Gas Generator Set Installation Manual-GF SeriesDoc. 17855, Rel. 03/20141-3• Remove all unnecessary grease and oil from the unit. Accumulated g

Natural Gas Generator Set Installation Manual-GF SeriesDoc. 17855, Rel. 03/20141-4KEEP THIS MANUAL NEAR THE GENSET FOR EASY REFERENCE

Natural Gas Generator Set Installation Manual-GF SeriesDoc. 17855, Rel. 03/20142-1Section 2 - Introduction2.1 About This ManualThis manual provides in

Natural Gas Generator Set Installation Manual-GF SeriesDoc. 17855, Rel. 03/20142-22.5 Standby Heating Devices In accordance with NFPA 110, Cummins NPo

Natural Gas Generator Set Installation Manual-GF SeriesDoc. 17855, Rel. 03/20143-1Section 3 - Installation3.1 Mounting the Generator SetGenerator set

Natural Gas Generator Set Installation Manual-GF SeriesDoc. 17855, Rel. 03/20143-23.1.4 Mechanical ConnectionsThe generator set mechanical system inst

Natural Gas Generator Set Installation Manual-GF SeriesDoc. 17855, Rel. 03/20143-3type. The electric valve should be wired so that the valve is closed

Natural Gas Generator Set Installation Manual-GF SeriesDoc. 17855, Rel. 03/20143-4WARNINGBattery electrolyte (sulfuric acid) is highly caustic and can

Natural Gas Generator Set Installation Manual-GF SeriesDoc. 17855, Rel. 03/20143-51. Rain Cap2. Drip Cap3. Holes in End of Inner Sleeve4. Roof5. Thimb

This manual contains proprietary information to equipment produced by Cummins NPower LLC and Cummins Inc. and is being supplied solely for the purpose

Natural Gas Generator Set Installation Manual-GF SeriesDoc. 17855, Rel. 03/20143-61. Exhaust Line2. Condensation Trap3. Valve Handle (shown in open po

Natural Gas Generator Set Installation Manual-GF SeriesDoc. 17855, Rel. 03/20143-76. Do not impose external force(s) on the catalyst housing greater t

Natural Gas Generator Set Installation Manual-GF SeriesDoc. 17855, Rel. 03/20143-83.8.3 PreparationWARNINGDo not touch the surface of the existing sil

Natural Gas Generator Set Installation Manual-GF SeriesDoc. 17855, Rel. 03/20143-93.8.4 3-Way Catalyst InstallationWARNINGTo reduce the possibility of

Natural Gas Generator Set Installation Manual-GF SeriesDoc. 17855, Rel. 03/20143-103.9 Air Fuel Setting and Emission Mea-surementThis procedure shall

Natural Gas Generator Set Installation Manual-GF SeriesDoc. 17855, Rel. 03/20143-113.15 Remote Radiator Cooling Require-ments (Available on All Models

Natural Gas Generator Set Installation Manual-GF SeriesDoc. 17855, Rel. 03/20143-12

Natural Gas Generator Set Installation Manual-GF SeriesDoc. 17855, Rel. 03/20144-1Section 4 - Controls4.1 Control System OverviewThe PowerCommand Cont

Natural Gas Generator Set Installation Manual-GF SeriesDoc. 17855, Rel. 03/20144-2Digital Connections: Connection points, other than relayed outputs,

Natural Gas Generator Set Installation Manual-GF SeriesDoc. 17855, Rel. 03/20144-3Figure 4-1 Switched B+: (Fused at 5 amps.) Same as Relay Connection

Cummins NPower LLC 1600 Buerkle Road White Bear Lake, MN 55110 Phone 651 636 1000 www.npower.cummins.com Cummins NPower LLC Generator Sets

Natural Gas Generator Set Installation Manual-GF SeriesDoc. 17855, Rel. 03/20144-4cables—Disconnect negative (-) cable first and reconnect last.CAUTIO

Natural Gas Generator Set Installation Manual-GF SeriesDoc. 17855, Rel. 03/20144-5prior to shipment. The installer must always check the stator lead t

Natural Gas Generator Set Installation Manual-GF SeriesDoc. 17855, Rel. 03/20144-64.7 Coolant Heater (Optional)CAUTIONThe coolant heater must not be o

Natural Gas Generator Set Installation Manual-GF SeriesDoc. 17855, Rel. 03/20144-74.7.3 Breather Heater (Optional)This heater is designed to prevent c

Natural Gas Generator Set Installation Manual-GF SeriesDoc. 17855, Rel. 03/20144-8

Natural Gas Generator Set Installation Manual-GF SeriesDoc. 17855, Rel. 03/20145-1Section 5 - Pre-Start PreparationBefore attempting the initial start

Natural Gas Generator Set Installation Manual-GF SeriesDoc. 17855, Rel. 03/20145-25.6 Emissions RequirementsWARNINGIt is the owner/operator’s responsi

Natural Gas Generator Set Installation Manual-GF SeriesDoc. 17855, Rel. 03/20145-31. Air-Fuel Mixture Test Port2. Solenoid Valve3. Demand Regulator 4.

Natural Gas Generator Set Installation Manual-GF SeriesDoc. 17855, Rel. 03/20145-45.7.4 Fuel Mixture AdjustmentsIMPORTANT: Always use Nox and CO test

Natural Gas Generator Set Installation Manual-GF SeriesDoc. 17855, Rel. 03/20146-1Section 6 - Installation Checklist6.1 General□ Generator set wattag

Cummins NPower LLC 1600 Buerkle Road White Bear Lake, MN 55110 Phone 651 636 1000 www.npower.cummins.com Limitations: This limited warrant

Natural Gas Generator Set Installation Manual-GF SeriesDoc. 17855, Rel. 03/20146-26.5 Exhaust System□ Operators are thoroughly briefed on the dangers

Natural Gas Generator Set Installation Manual-GF SeriesDoc. 17855, Rev. 03/20147-1Section 7 - Wiring Diagrams7.1 GeneralThis section consists of the s

Natural Gas Generator Set Installation Manual-GF SeriesDoc. 17855, Rev. 03/20147-2

13152120109J2021110643598J111920B+ INPUT (FUSED B+)B+ INPUT (FUSED B+)B+ INPUT (FUSED B+)B+ INPUT (FUSED B+)24712STARTER RELAY DRIVERCHASSIS GROUNDSWI

"J1"E-STOPC3"C3"J1"P1""J6"P1J6TERMINATING RESISTORS1C2"C2"ED3 DISPLAY"RESET""E-STOP&q

C5C4C1C6FIELDWINDING(F1) X+(F2) XX-312PMGALTERNATORRECONNECTTERMINAL BLOCKNVWUC1C1C1C2CAUTO CAD-+BATTERYS TERMMOTSTARTERENGINE ALTERNATORCDC4CDCC5DBC3

13152120109J2021110643598J111920B+ INPUT (FUSED B+)B+ INPUT (FUSED B+)B+ INPUT (FUSED B+)B+ INPUT (FUSED B+)24712STARTER RELAY DRIVERCHASSIS GROUNDSWI

"J29"E-STOPC3"C3"J29"J1""J6"J1"J28"J28J6TERMINATING RESISTORS1C2"C2"ED3 DISPLAY"RESET

C5C4C1C6FIELDWINDING(F1) X+(F2) XX-312PMGALTERNATORRECONNECTTERMINAL BLOCKNVWUC1C1C1C2CAUTO CAD-+BATTERYS TERMMOTSTARTERENGINE ALTERNATORCDC4CDCC5DBC3

114152120109J2021110643598B+ INPUT (FUSED B+)B+ INPUT (FUSED B+)B+ INPUT (FUSED B+)B+ INPUT (FUSED B+)24712STARTER RELAY DRIVERCHASSIS GROUNDFSO LOW S

Natural Gas Generator Set Installation Manual-GF SeriesDoc. 17855, Rel. 03/2014TOC-iTable of ContentsWarranty InformationSection 1 - Safety1.1 Advisor

AUTO CAD"J29"E-STOPC3"C3"J29"J1""J6"J1"J28"J28J6TERMINATING RESISTORS1C2"C2"ED3 DISPLAY&qu

C5C4C1C6FIELDWINDING(F1) X+(F2) XX-312PMGALTERNATORRECONNECTTERMINAL BLOCKNVWUC1C1C1C2CAUTO CAD-+BATTERYS TERMMOTSTARTERENGINE ALTERNATORCDC4CDCC5DBC3

13152120109J2021110643598J111920B+ INPUT (FUSED B+)B+ INPUT (FUSED B+)B+ INPUT (FUSED B+)B+ INPUT (FUSED B+)24712STARTER RELAY DRIVERCHASSIS GROUNDSWI

AUTO CADC5"J29"E-STOPC3"C3"J29"J1""J6"J1"J28"J28J6TERMINATING RESISTORS1C2"C2"ED3 DISPLAYC

C5C4C1C6FIELDWINDING(F1) X+(F2) XX-312PMGALTERNATORRECONNECTTERMINAL BLOCKNVWUC2C1C1C2C1AUTO CAD-+BATTERYS TERMMOTSTARTERENGINE ALTERNATORCDC4CDCC5DBC

13152120109J2021110643598J111920B+ INPUT (FUSED B+)B+ INPUT (FUSED B+)B+ INPUT (FUSED B+)B+ INPUT (FUSED B+)24712STARTER RELAY DRIVERCHASSIS GROUNDSWI

AUTO CADC5"J29"E-STOPC3"C3"J29"J1""J6"J1"J28"J28J6TERMINATING RESISTORS1C2"C2"ED3 DISPLAYC

C5C4C1C6FIELDWINDING(F1) X+(F2) XX-312PMGALTERNATORRECONNECTTERMINAL BLOCKNVWUC2C1C1C2C1AUTO CAD-+BATTERYS TERMMOTSTARTERENGINE ALTERNATORCDC4CDCC5DBC

114152120109J2021110643598B+ INPUT (FUSED B+)B+ INPUT (FUSED B+)B+ INPUT (FUSED B+)B+ INPUT (FUSED B+)24712STARTER RELAY DRIVERCHASSIS GROUNDFSO LOW S

AUTO CADC5 C4SPLICE DETAILSC13C6CR12SPL ASPL BSPL CSPL DSTAGGER SPLICES IN SHIELDED CABLEPCC3300J25J26J20J22J12CT1CT2CT3TB7TB9TB15J14TB10TB8TB5TB3TB1A

Natural Gas Generator Set Installation Manual-GF SeriesDoc. 17855, Rel. 03/2014TOC-iiTable of Contents3.14 Radiator Set Cooling Requirements . . . .

C5C4C1C6FIELDWINDING(F1) X+(F2) XX-312PMGALTERNATORRECONNECTTERMINAL BLOCKNVWUC2C1C1C2C1AUTO CAD-+BATTERYS TERMMOTSTARTERENGINE ALTERNATORCDC4CDCC5DBC

13152120109J2021110643598J111920B+ INPUT (FUSED B+)B+ INPUT (FUSED B+)B+ INPUT (FUSED B+)B+ INPUT (FUSED B+)24712STARTER RELAY DRIVERCHASSIS GROUNDSWI

21110643598DISCRETE INPUT RETURNLOCAL E-STOPMANUAL COMMANDPCC NET SHIELDPCC NET APCC NET BSYSTEM WAKEUPBATT -AUTO COMMANDJ252J615J235J143FUSED B+GND24

E-STOPJ2J1J6"E-STOP""F8""F9""F10"C1C6122233TERMINAL STRIP DETAIL112"F4"24"F5"F1F5F4F8F9F10

AUX1052OIL PRESSURE SENDER RETURN3OIL PRESSURE SENDER4GOVERNOR -8MAGNETIC PICK UP SHIELD9MAGNETIC PICK UP SUPPLY10MAGNETIC PICK UP RETURN11COOLANT TEM

"J29"E-STOPJ29"J1""J6"J1"J28"J28J6"E-STOP""F3""F8""F9""F10"C

Cummins NPower, LLC1600 Buerkle RdWhite Bear Lake, MN 55110Customer Assistance Center: 1 866 831 7620 www.cumminsnpower.com

Table of ContentsNatural Gas Generator Set Installation Manual-GF SeriesDoc. 17855, Rel. 03/2014TOC-iii

Natural Gas Generator Set Installation Manual-GF SeriesDoc. 17855, Rel. 03/2014TOC-ivTable of Contents

Natural Gas Generator Set Installation Manual-GF SeriesDoc. 17855, Rel. 03/20141-1Section 1 - SafetyIMPORTANT SAFETY INSTRUCTIONS - This manual contai