CUMMINS P5350c Especificaciones

Operator ManualPortable Generator SetEGMBD, P5350ecEGMBD, P5350ceEGMBD, P5500ecEGMBE, P5450ecEGMBE, P5450ecEGMBE, P5550ecEGMBE, P6500ecEnglish

2. Introduction 12-2008FIGURE 2. NAMEPLATE LOCATION FOR P5500 AND P65006 914-0103 (Issue 3)

12-2008 2. IntroductionNo. Description No. Description1 Fuel Tank Cap 6 Recoil Starter Grip2 Fuel Gauge 7 Control Panel3 Choke Lever 8 Muffler4 Fuel L

2. Introduction 12-2008No. Description No. Description1 Fuel Tank Cap 6 Recoil Starter Grip2 Fuel Gauge 7 Battery3 Choke Lever 8 Control Panel4 Fuel V

2.3 Wheel Kit2.4 Fuel RequirementsWARNING: Evaporative starting fluids, such as ether, are highly explosive which canCAUTION: Methanol is corrosive to

2.5 Assembly InstructionsWARNING: The generator set is heavy. Dropping the generator set can cause severeCAUTION: Too little oil can cause severe engi

12-2008 2. Introduction4. Install the wheel and axle assembly (axle assembly and wheel assemblies).a. Remove the rubber pads secured to the frame wher

2.7 Engine Oil Recommendations2.8 Starting Battery2. Introduction 12-2008Use American Petroleum Institute (API) performance class SL or SJ engine oil

3 Starting and Running the Generator3.1 Control PanelSetThe control panels are illustrated below. The control switches, meters, output receptacles, an

3. Starting and Running the Generator Set 12-2008No. Description No. Description1 On/Off Switch 5 AC Circuit Breaker Reset2 Earth Ground Lug 6 One 120

12-2008 3. Starting and Running the Generator SetNo. Description No. Description1 On/Off Switch 5 AC Circuit Breaker Reset2 Earth Ground Lug 6 One 120

3. Starting and Running the Generator Set 12-2008No. Description No. Description1 Start/On/Off Switch 5 AC Circuit Breaker Reset2 Earth Ground Lug 6 O

12-2008 3. Starting and Running the Generator SetNo. Description No. Description1 Start/On/Off Switch 5 AC Circuit Breaker Reset2 Earth Ground Lug 6 O

3. Starting and Running the Generator Set 12-2008No. Description No. Description1 Start/On/Off Switch 7 Two 120 VAC, 20A Receptacles (GFCI)2 DC Breake

3.2 Pre-Start ChecksDANGER: EXHAUST GAS IS DEADLY! THE INDOOR USE OF A GENERATOR SET12-2008 3. Starting and Running the Generator SetCAN KILL QUICKLY.

WARNING: Moving parts can cause severe personal injury or death. Hot exhaust partsWARNING: Gasoline is highly flammable and expolsive and can be ignit

CAUTION: The voltage surge at startup can damage appliances such as TVs, microwave3.3.1 Using the Electric Starter3.3.2 Using the Recoil Starter12-200

3.4 Stopping the Generator SetWARNING: Gasoline is highly flammable and explosive which can result is severe3. Starting and Running the Generator Set

3.5 Powering Tools and AppliancesCAUTION: Continuous overloading can damage the generator set due to overheating. Make3.5.1 Voltage Selector Switch3.5

CAUTION: Excessive power draw can overload the generator set. A motor draws much more3.5.3 High Altitude3. Starting and Running the Generator Set 12-2

3.6 Charging BatteriesWARNING: Ignition of explosive battery gases can cause severe personal injury orNOTE: The battery on electric-start models has i

Table of Contents1. SAFETY PRECAUTIONS ...

3.10 Electrical Interference with Communications or3.11 Exercising the Generator Set3.12 Engine Break-In3.13 Out-of-Service Protection3.13.1 Storing t

3.13.2 Returning the Generator Set to Service12-2008 3. Starting and Running the Generator SetNo. Description1 Fuel Drain BoltFIGURE 16. CARBURETOR DR

3. Starting and Running the Generator Set 12-2008This page is intentionally blank.28 914-0103 (Issue 3)

4 Maintenance4.1 Maintenance ScheduleWARNING: Contact with a hot generator set can cause severe burns. Always allow theWARNING: Accidental starting of

4.2 General InspectionsWARNING: Contact with a hot generator set can cause severe burns. Always allow theCAUTION: A clogged flywheel air inlet screen

4.4 Air Filter Maintenance12-2008 4. MaintenanceNo. Description No. Description1 Oil Filler Cap 4 Upper Level2 Oil Drain Bolt 5 Lower Level3 Oil Fill

4.5 Battery MaintenanceWARNING: Ignition of explosive battery gases can cause severe personal injury orCAUTION: If the generator set will be used befo

4.6 Fuel Sediment Cup Cleaning4.7 Spark Plug Maintenance12-2008 4. MaintenanceFIGURE 19. BATTERY MOUNTINGRefer to the "Maintenance Schedule"

WARNING: Contact with hot generator parts can cause severe burns. Always allow the4.8 Cleaning the Generator SetWARNING: Wear safety glasses to protec

CAUTION: Cleaning the generator set with a pressure washer can cause damage to the4.9 Cleaning the Spark ArresterWARNING: Contact with a hot muffler c

Table of Contents 12-20084.2 General Inspections ...

4. Maintenance 12-2008This page is intentionally blank.36 914-0103 (Issue 3)

5 TroubleshootingWARNING: Many troubleshooting procedures or replacement of parts present hazardsWARNING: Contact with a hot generator set can cause s

WARNING: Many troubleshooting procedures or replacement of parts present hazardsWARNING: Contact with a hot generator set can cause severe burns. Alwa

WARNING: Many troubleshooting procedures or replacement of parts present hazardsWARNING: Contact with a hot generator set can cause severe burns. Alwa

WARNING: Many troubleshooting procedures or replacement of parts present hazardsWARNING: Contact with a hot generator set can cause severe burns. Alwa

6 SpecificationsTABLE 4. SPECIFICATIONS FOR P5350 AND P5350C (EGMBD) P5550E, P5450E, AND P5450EC(EGMBE)P5350 and P5350c P5450e and P5450ecP5550e (EGMB

6. Specifications 12-2008TABLE 5. SPECIFICATIONS FOR P5500 (EGMBD) AND P6500 (EGMBE)GENERATOR P5500 (EGMBD) P6500 (EGMBE)AC OUTPUT:Frequency (Hertz) 6

7 Important Information for CaliforniaNOTE: This section applies to P5350C and P5450ec models. It also applies to P5500Usersand P6500 models built bef

7. Important Information for California Users 12-2008This page is intentionally blank.44 914-0103 (Issue 3)

1 Safety PrecautionsDANGER: This symbol alerts you to an immediate hazard that will result inWARNING: This symbol alerts you to a hazard or unsafe pra

Cummins Power Generation1400 73rd Ave. NEMinneapolis, MN 55432 USAPhone 1 763 574 5000Toll-free 1 800 888 6626Fax 1 763 574 5298Email www.cumminsonan

1.3 Generator Voltage is Deadly1.4 Moving Parts Can Cause Severe Personal Injury or1.5 Battery Gases Are Explosive1.6 General Precautions1. Safety Pre

12-2008 1. Safety Precautions· Keep a multi-class ABC fire extinguisher readily at hand. Class A fires involve ordinarycombustible materials, such as

1. Safety Precautions 12-2008This page is intentionally blank.4 914-0103 (Issue 3)

2 Introduction2.1 About This Manual2.2 Model IdentificationWARNING: Many troubleshooting procedures or replacement of parts present hazardsThis manual