CUMMINS Home Standby Generator Set Manual de instalación descargar pdf (Pagina 17)

100

4-2010 3. Step-By-Step Outline of Installation

RSS 200-6869 X

NOTE: Model RSS 100-6634 and RSS 200-6635 transfer switches do not incorporate

a utility circuit breaker and therefore must be connected through a Service

Entrance Utility Panel incorporating the utility circuit breaker.

Perform Generator Set Configuration when ready to start up the generator set.

FIGURE 1. PARTIAL COVERAGE LOAD CONNECTIONS (TRANSFER SWITCH WITHOUT

CONTROLLER)

FIGURE 2. FULL COVERAGE LOAD CONNECTIONS (TRANSFER SWITCH WITHOUT

CONTROLLER, ONE CIRCUIT BREAKER)

A029V088 (Issue 2) 13

1 2 ... 12 13 14 15 16 17 18 19 20 21 22 ... 99 100

Installation Manual 1
Table of Contents 3
Table of Contents 4-2010 4
1.1 Save These Instructions 5
1.2 General Precautions 5
1.4 Engine Exhaust is Deadly 6
1.6 Batteries Can Explode 6
A029V088 (Issue 2) 3 7
4 A029V088 (Issue 2) 8
2 Introduction 9
2. Introduction 4-2010 10
6 A029V088 (Issue 2) 10
4-2010 2. Introduction 11
A029V088 (Issue 2) 7 11
8 A029V088 (Issue 2) 12
A029V088 (Issue 2) 9 13
3.1.2.1 Materials Required 14
A029V088 (Issue 2) 11 15
3.1.2.2 Tools Required 16
A029V088 (Issue 2) 13 17
14 A029V088 (Issue 2) 18
A029V088 (Issue 2) 15 19
3.3 Preparing the Site 20
A029V088 (Issue 2) 17 21
3.6.2 Grounding 22
A029V088 (Issue 2) 19 23
3.6.5 Operator Panel 24
A029V088 (Issue 2) 21 25
· Input: 12Vdc, Max 0.5 Amp 26
· Mounting: No restrictions 26
3.6.8 Battery 28
3.7 Fuel System 29
3.7.1 Fuel Line Connections 30
3.7.3 Natural Gas Fuel System 31
28 A029V088 (Issue 2) 32
3.7.4 Propane Fuel System 33
30 A029V088 (Issue 2) 34
A029V088 (Issue 2) 31 35
3.8 Engine Exhaust 36
Descriptions 37
4.2 Screen Descriptions 38
4.2.2 Set Exercise Schedule 39
4.2.4 Event Log 39
4.2.5 Fault Log 40
4.2.8 Saving Changes 41
FIGURE 25. SAVE SCREEN 42
Worksheet: 43
40 A029V088 (Issue 2) 44
FIGURE 26. ETHERNET CONNECTOR 45
42 A029V088 (Issue 2) 46
Password: Cummins 47
FIGURE 29. GENERATOR SET HOME 47
44 A029V088 (Issue 2) 48
6.4 Email Setup Parameters 49
FIGURE 37. EMAIL ADDRESSES 50
6.6 Help Hotline 51
48 A029V088 (Issue 2) 52
A029V088 (Issue 2) 49 53
50 A029V088 (Issue 2) 54
7 Operation 55
7.2 In-Home Operator Panel 56
7.3 Typical Operation 57
7. Operation 4-2010 58
54 A029V088 (Issue 2) 58
4-2010 7. Operation 59
A029V088 (Issue 2) 55 59
56 A029V088 (Issue 2) 60
A029V088 (Issue 2) 57 61
7.4 To Enable/Disable Standby 62
7.6.1 Fault Screen 63
7.6.2 Maintenance Due Screen 63
7.7 Genset Status 64
7.8.1 Brightness and Contrast 65
7.8.2 Software Info 66
7.9 Event Log 67
7.10 Fault Log 68
7.11 Exercise Settings 69
7.12 Time Setup 70
7.13 Load Management 71
7.13.2 Manual Load Management 72
8 Startup and Configuration 73
70 A029V088 (Issue 2) 74
A029V088 (Issue 2) 71 75
72 A029V088 (Issue 2) 76
A029V088 (Issue 2) 73 77
74 A029V088 (Issue 2) 78
8.7 Generator Adjustments 79
76 A029V088 (Issue 2) 80
Troubleshooting 81
A029V088 (Issue 2) 79 83
80 A029V088 (Issue 2) 84
A029V088 (Issue 2) 81 85
82 A029V088 (Issue 2) 86
84 A029V088 (Issue 2) 88
A029V088 (Issue 2) 85 89
86 A029V088 (Issue 2) 90
A029V088 (Issue 2) 87 91
FIGURE 71. HARNESS LABEL 92
A029V088 (Issue 2) 89 93
90 A029V088 (Issue 2) 94
A029V088 (Issue 2) 91 95
92 A029V088 (Issue 2) 96
FIGURE 76. OUTLINE DRAWING 97
94 A029V088 (Issue 2) 98

Comentarios a estos manuales

Sin comentarios

CUMMINS Home Standby Generator Set Manual de instalación Pagina 17

Comentarios a estos manuales

Relacionado con productos y manuales para Generadores De Poder CUMMINS Home Standby Generator Set